In this Dec. 9, 2016  photo, courtesy of Pacific Northwest National Laboratory, PNNL microbiologist Robert Jeters sprinkles PNNL's chemically modified sawdust onto a small oil spill inside the Arctic simulation lab, where researchers mimic extreme freezing conditions and make icy slush that is similar to what is found on the surface of the Arctic Sea during a demonstration of sawdust oil recovery material research at the PNNL in Richland, Wash. (Pacific Northwest National Laboratory via AP)

In this Dec. 9, 2016 photo, courtesy of Pacific Northwest National Laboratory, PNNL microbiologist Robert Jeters sprinkles PNNL's chemically modified sawdust onto a small oil spill inside the Arctic simulation lab, where researchers mimic extreme freezing conditions and make icy slush that is similar to what is found on the surface of the Arctic Sea during a demonstration of sawdust oil recovery material research at the PNNL in Richland, Wash. (Pacific Northwest National Laboratory via AP)

Treated sawdust may help sop up, burn off Arctic oil spills

  • By Dan Joling
  • Wednesday, December 14, 2016 10:33pm
  • News

ANCHORAGE — Federal researchers looking for ways to contain petroleum spills in frigid Arctic waters are investigating whether a powder form of humble sawdust can provide a solution.

Researchers at the Department of Energy’s Pacific Northwest National Laboratory are testing chemically modified wood flour to determine whether it can enhance the burning of crude oil after a spill.

Tests of small batches treated with components of vegetable oil indicate the material will grab onto crude oil and help keep it near the surface. PNNL senior research scientist George Bonheyo, who is also a research professor of bioengineering at Washington State University, calls the material “incredibly buoyant, ice repelling and water-repelling.”

“It really, really loves oil,” Bonheyo said. “It absorbs at least five times its weight in oil.”

Environmental groups say challenges with cleaning an oil spill are amplified in the Arctic and it’s one of their primary objections to drilling off Alaska’s northern coast. The location is far from ports and other infrastructure taken for granted at drilling sites such as the Gulf of Mexico. Storms are fierce and Arctic waters can be open, frozen or partially covered with ice ranging from floes to slush.

Mechanical recovery has not proven effective because ice can jam skimmers. Researchers at the PNNL lab have focused on burning and bioremediation.

“The point with doing a burn is that it allows you within a matter of minutes to remove upward of 90 percent of the oil from the water,” Bonheyo said.

To burn, he said, untreated crude oil must be fresh and at least 3mm thick, a little more than two stacked dimes. Early results from lab tests of the chemically treated sawdust indicate the material will help keep an oil slick together in the face of buffeting by wind, waves or ice, Bonheyo said, and allow it to burn in thinner amounts.

“We know we can get below 1mm,” he said. “We don’t know exactly what the minimum thickness is.”

Crude oil weathers when absorbed by the material but remains buoyant for at least four months.

“It works very well at holding a spill together. It seems to act kind of like a wick, allowing the volatile, flammable components to rise up to the surface to facilitate an efficient burn,” Bonheyo said.

Bonheyo has a background in research on ship hulls to preventing fouling by organisms. Researchers are looking into adding a bioremediation element to the chemically modified sawdust. Mixtures of organisms adapted for different hydrocarbons, and adapted for different environments, could be added to the wood-based product.

“The idea there is, if any of the oil with the sawdust escaped a burn site, the microbes would be there to consume the escaped oil,” Bonheyo said.

Researchers have conducted burn tests of Alaska North Slope crude oil and Gulf of Mexico crude in warm water at the Navy and Coast Guard Joint Marine Test Facility near Mobile, Alabama. Cold water testing is underway. Researchers also are analyzing residue of material that remains after burning.

Researchers during tests have shaken the powdery material onto water surfaces or spread it with a modified leaf blower. In the real world, Bonheyo suggested, it might be dispersed the way powdery materials are distributed by crop dusters.

More in News

In this Sept. 21, 2017, file photo, former vice presidential candidate Sarah Palin speaks at a rally in Montgomery, Ala. Palin is on the verge of making new headlines in a legal battle with The New York Times. A defamation lawsuit against the Times, brought by the brash former Alaska governor in 2017, is set to go to trial starting Monday, Jan. 24, 2022 in federal court in Manhattan. (AP Photo/Brynn Anderson, File)
Palin COVID-19 tests delay libel trial against NY Times

Palin claims the Times damaged her reputation with an opinion piece penned by its editorial board

COVID-19. (Image courtesy CDC)
COVID-19 at all-time high statewide

The state reported 5,759 new cases sequenced from Jan. 21-23

Volunteers serve food during Project Homeless Connect on Jan. 25, 2018, at the Soldotna Regional Sports Complex in Soldotna, Alaska. (Erin Thompson/Peninsula Clarion file)
Project Homeless Connect to provide services, support on Wednesday

The event will be held at the Soldotna Sports Complex on Wednesday from 9 a.m. to 3 p.m.

The logo for the Kenai Peninsula Borough School District is displayed inside the George A. Navarre Borough Admin Building on Thursday, July 22, 2021 in Soldotna, Alaska. (Ashlyn O’Hara/Peninsula Clarion)
Schools aim for business as usual as cases reach new highs

On Monday, there were 14 staff members and 69 students self-isolating with the virus

Triumvirate Theatre is seen on Monday, Feb. 22, 2021 in Nikiski, Alaska. The building burned in a fire on Feb. 20. (Ashlyn O’Hara/Peninsula Clarion)
Triumvirate construction on hold as theater seeks additional funding

The new theater is projected to cost around $4.7 million.

The logo for the Kenai Peninsula Borough School District is displayed inside the George A. Navarre Borough Admin Building on Thursday, July 22, 2021 in Soldotna, Alaska. (Ashlyn O’Hara/Peninsula Clarion)
KPBSD schools to start 2 hours late Tuesday

Due to weather, all but 4 schools will be delayed

Data from the state of Alaska show a steep increase in COVID-19 cases in January 2022. (Department of Health and Social Services)
Omicron drives COVID spike in Alaska as officials point to decreasing cases in eastern US

On Friday, the seven-day average number of daily cases skyrocketed to 2,234.6 per 100,000 people

Dana Zigmund/Juneau Empire
Dan Blanchard, CEO of UnCruise Adventures, stands in front of a ship on May 14, 2021.
Smooth sailing for the 2022 season?

Cautious optimism reigns, but operators say it’s too early to tell.

Former Alaska Assistant Attorney General Elizabeth Bakalar speaks a news conference on Jan. 10, 2019, in Anchorage, Alaska, after she sued the state. A federal judge on Thursday, Jan. 20, 2022, ruled that Bakalar was wrongfully terminated by the then-new administration of Alaska Gov. Mike Dunleavy for violating her freedom of speech rights. (AP File Photo/Mark Thiessen, File)
Judge sides with attorney who alleged wrongful firing

Alaska judge says the firing violated free speech and associational rights under the U.S. and state constitutions.

Most Read